Paddlingsfabriken

Paddlingsfabriken - Melontatehdas

Fun, Safe and enoyable learning experience in the wonderful archipelago
  • Schrift vergrößern
  • Standard-Schriftgröße
  • Schriftgröße verkleinern
Home Kajak Construction
Construction

Wood composite or full fiberglass kayak - which is better?

Drucken PDF
There are no translations available.

Contrary to common perception wood composite kayaks are stronger than fiberglass and plastic kayaks. The construction is sandwich. External layers (inside and outside) of fiberglass & epoxy with a wooden core in our constructions. OneOceanKayaks says a lot about the construction on their webpage "Composite Sandwich Core Panel - mechanics and principals". I wanted to add a video demonstration to convince sceptics that think pure plastic or fiberglass is less trouble. Find the video I am referring to lower down. My daughter is rocking the boat on the ground while I stand on the deck of the other end. No harm done.

A mended fiberglass boat is likely to require more skills to reach the original strength. A fiber boat with comparable weight to the wood composite is also likely to break sooner ie. more mending needed. Add the lesser risk of dropping or hurting yourself with handling a 5-10 kilo lighter boat.

If you plan to break and dump the broken kayak for the winter, then you should go for the plastic. Water and ice will not make you worse off for the spring when you want to fix that leaking crack. What you need is similar plastic and a substancial amount of heat to quickly melt some new plastic and bond it with the edges.   Fiberglass and wood kind of rots when swamped with water, but the rot does not happen much faster with epoxy&fiberglass laminated wood than with fiberglass that has lost its protecting gelcoat. The styren resin used when building fiberglass boats soaks water when exposed, as opposed to epoxy that is water resistant in comparison. The wood also soaks water but only to a limited amount. And since air is blocked by the water few microbes will enter the exposed wooden parts of the core. The soaking is demonstrated in the video referred to in this article. I also had a laminated piece out in the snow over the winter, big parts of wood exposed in the cuts, and minimal harm seen. Sadly I burnt it some weeks ago and could not add it to this video.

Mending a wood composite kayak can require as little as adding some epoxy to the surface. In the worse case you would push back the wood sticks so they match, dry the wood and soak the area with epoxy. Then sand it and add a new coating of fiberglass and epoxy. Sand it again to the finnish you need, and it is as strong as it was. Optionally you might want to glue in some new wood with the same colors and then finding the old damage is guesswork.

Mending fiberglass boats is not really difficult but is likely to require a bigger patch and might need something to act as a mold. Small cracks in the gelcoat (the colored hard outer shell) need to be opended and cleaned. Start with one side. Make sure the structure stays until you have enough stiffness to avoid molding/modelling. You can use epoxy. In fact epoxy is gerenrally recommended for repairs. Once you have replaced the broken old fibers with intact fibers, and sufficient thickness, then space for the colored gelcoat is grinded by sanding. And then apply gelcoat, with some repeated sanding for a nice finish.

To have and to hold a dear kayak for years and generations it is better be enjoyable and inspiering by looks and performance. Invest in a wooden kayak.

 

Zuletzt aktualisiert am Mittwoch, den 07. Dezember 2011 um 23:22 Uhr
 

Paperikajakin rakentaminen - pienoismallina

Drucken PDF
There are no translations available.

Kajakinrakennus unelman toteuttamiseen riittää hyvin rajoitettu tila ja alle tunnin työpanos. Mallin voi tulostaa 200gramman A4 paperille ja siitä rakentaminen alkaa. Tarvitset sakset ja teippiä. Malli on ladattavissa alla olevasta linkistä, ja maksu onnistuu PayPal palvelun kautta luottokortilla.

Cut and tape kayak for one 200g paper copy (kajakfr.pdf)
Price: EUR €2.00

 

Alla olevassa videossa rakennetaan lähestulkoon samaa kajakkimallia.

Reippaasti vain kokeilemaan. Ehkä tällä kokemuksella rakennat seuraavaksi vanerilevykajakin samansuuntaisesti kuin miten meidän piirtämä Fragrance Ply (vaneri) on rakennettu.

Zuletzt aktualisiert am Sonntag, den 04. Dezember 2011 um 14:03 Uhr
 

Das Bauen eines Streifen-Kajaks

Drucken PDF

Eine kleine Zusammenfassung der notwendigen Arbeitsschritte:
 

  • Holzplanken werden der Länge nach in Streifen von normalerweise 18mm x 7mm gesägt. 
  • Die Streifen werden angeschrägt und gehobelt.
  • Eine Serie von Formen (ähnlich Schotten) werden auf einem sog. Strongback, der Wirbelsäule dieser Bootsbauart, angebracht und ausgerichtet, um dem Kajak die gewünschte Form zu geben.
  • Die Streifen werden der Reihe nach auf diese Form aufgebracht und miteinander verklebt.
  • Der so erhaltene Rumpf wird von aussen abgezogen/gehobelt und geschliffen, bis er die gewünschte Glätte hat. 
  • Die Innenseite des Rumpfes wird geschliffen und mit Epoxy/Fiberglas beschichtet.
  • Die Streifen des Decks werden auf die Formen aufgebracht und verklebt. 
  • Wieder abziehen/hobeln, schleifen und Epoxy/Fiberglas beschichten.
  • Packluken und Sitzöffnung werden gebaut, Sitze eingebaut oder selbst gebaut, ein-/ausfahrbare Flosse installiert.
  • Auslegung des Decks wird geplant und Beschläge gebaut/installiert.
  • Deck und Rumpf werden mit Epoxy und Fiberglas zusammengefügt.
  • Schleifen, noch ein bisschen Epoxy für ein schönes Finish. UV-Schutz drauf. Fertig! 
Zuletzt aktualisiert am Freitag, den 04. November 2011 um 09:45 Uhr
 

Holz und Epoxy Kajaks - bestellen Sie Ihres

Drucken PDF

Die Paddlingsfabriken (www.paddlingsfabriken.fi) designed und baut Kajaks für den eigenen Gebrauch und auch zum Verkauf. Bis dato sind vier Kajaks gebaut worden. Im Vergleich mit gleichwertigen fiberglas und plastik Kajaks sind diese Epoxy laminierten Boote leichter und stabiler. Kajaks dieser Streifenbauweise sind auch kleine Kunstwerke die gerne die Aufmerksamkeit und Bewunderung anderer auf sich ziehen.

Da jeder Kajak handgefertigt wird, können individuelle Wünsche natürlich gerne bedacht werden. Die Sitzluke kann z.B. kleiner oder grösser gesteltet werden, ganz nach Ihrem Wunsch. Die Grösse und Anzahl der Stauluken, das Steuer, das Boot Volumen usw. können nach Ihrem Wunsch gestaltet werden.

Die vier bisher gebauten Kajaks sind: ein schneller im "Surfski"-Stil gehaltener jedoch geschlossener Kajak; ein Kleinkindkajak; ein traditioneller Meeres-Kajak sowie eine etwas schnellere schmalere Variante des eben genannten Meeres-Kajaks. Der zu erwartende Preis eines von uns gebauten Kajaks in der Streifenbauweise würde zwischen ca. 1900,- und 5000,-€ liegen, was ganz auf die gewünschten Ornamente, die Wahl der Fiberglasmatte, das Finish und die Ausrüstung ankommt.

Zuletzt aktualisiert am Donnerstag, den 11. August 2011 um 20:08 Uhr